BMW G 650 GS (1981–2021) maintenance schedule & recalls

BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.

Remedy: DEALERS WILL CHECK AND INSTALL A CORRECT CIRCLIP, ALONG WITH A NEW SPACER BUSHING, WHEEL BEARINGS, AND SHAFT SEALING RINGS FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

BMW IS RECALLING 1,391 MY 2007 G650X CHALLENGE, COUNTRY, AND MOTO MOTORCYCLES. THE FUEL LINES MAY HAVE BEEN DAMAGED DURING PRODUCTION, AND COULD DEVELOP A LEAK. THE LEAK COULD OCCUR EITHER THROUGH THE FABRIC INLAY AT THE END OF THE LINE, OR, THROUGH A CRACK IN THE ACTUAL LINE.

Remedy: DEALERS WILL INSPECT AND REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN DURING APRIL 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

BMW IS RECALLING CERTAIN MODEL YEAR 2007 AND 2008 G 650 X COUNTRY, G 650 X CHALLENGE, AND G650 X MOTO MOTORCYCLES MANUFACTURED FROM NOVEMBER 29, 2006 THROUGH MAY 19, 2008. OVER TIME, THE ROLL GEAR PIN'S MOUNTING ATTACHMENT COULD BREAK.

Remedy: DEALERS WILL REPLACE THE ROLL GEAR PIN'S MOUNTING ATTACHMENTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

ON CERTAIN MOTORCYCLES, THE FUEL PUMP WIRING SET HAS NOT BEEN MANUFACTURED ACCORDING TO SPECIFICATION. THE CONTACTS IN THE PLUG FOR THE FUEL PUMP CAN BREAK.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP UNIT WIRING SET FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

ON CERTAIN MOTORCYCLES, A LEFT-SIDE CHAIN TENSIONER HAS BEEN INCORRECTLY INSTALLED ON THE RIGHT SIDE. AS A RESULT, A HEX NUT, WHICH IS USED TO SECURE THE CHAIN TENSIONER, IS IMPROPERLY SEATED AGAINST THE TENSIONER.

Remedy: DEALERS WILL INSTALL A NEW RIGHT SIDE CHAIN TENSIONER FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 13, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

BMW of North America, LLC (BMW) is recalling certain model year 2013-2016 BMW G650GS motorcycles manufactured March 8, 2013, to October 12, 2015, and 2013-2015 BMW G650GS Sertao motorcycles manufactured March 8, 2013, to May 23, 2014. The affected motorcycles may stall during operation due to an engine control unit (ECU) software issue.

Remedy: BMW will notify owners, and dealers will update the ECU software, free of charge. The recall is expected to begin November 18, 2016. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall supersedes recall 15V-537. Motorcycles that were repaired under that recall need to have their software updated again as part of this campaign.

BMW of North America, LLC (BMW) is recalling certain model year 2013-2015 G 650 GS motorcycles manufactured March 8, 2013, to March 2, 2015, and 2013-2014 G 650 GS Sertao motorcycles manufactured March 8, 2013, to May 23, 2014. The affected motorcycles may stall when they are idling and the clutch lever is pulled in.

Remedy: BMW will notify owners, and dealers will install a revised version of the engine control unit software, free of charge. The recall began on October 14, 2015. Owners may contact BMW customer service at 1-800-525-7417 or by email at [email protected].